Product ID:ROYCO 885A
MSDS Date:07/18/1995
FSC:9150
NIIN:01-018-8959
Status Code:A
MSDS Number: CLPQP

ROYAL LUBRICANTS COMPANY INC.

MERRY LN
EAST HANOVER, NJ 07936-0518
US

Emergency Phone: (201)887-7410

Info Phone: 973-887-7411/7410

Cage: 07950

ROYAL LUBRICANTS COMPANY INC.

518 EAST HANOVER, NJ 07936 US

Telephone: 973-887-7411/7410

Cage: 07950

CONSIST OF THE FOLLOWING INGREDIENTS

SYNTHETIC ESTERS

CAS: 122-62-3

RTECS: VS1000000

BARIUM DINONYLNAPHTHALENE SULFONATE

CAS: 25619-56-1

OSHA PEL 0.5 MG/M3

ACGIH TLV: 0.5 MG/M3

BUTYLATED HYDROXY TOLUENE

CAS: 128-37-0

RTECS: GO7875000

ACGIH TLV: 10 MG/M3

Health Hazards Acute and Chronic:EYE CONTACT: BASED ON PRESENCE OF
COMPONENT 2 AND 3, PRODUCT IS IRRITATING TO THE EYES. INHALATION:
INHALTION OF VAPORS (GENERATED AT HIGH TEMPERTURES ONLY) OR OIL
MIST MAY BE MILDLY IRRITATING TO THE NOSE, THROAT AND RESPIRATORY
TRACT. INGESTION: INGESTION OF PRODUCT MAY RESULT IN VOMITING;
ASPIRATION (BREATHING) OF VOMITUS INTO THE LUNGS MST BE AVOIDED AS
EVEN SMALL QUANTITIES MAY RESULT IN ASPI RATION PNEUMONITIS.
Explanation of Carcinogenicity:THIS PRODUCT DOES NOT CONTAIN ANY
CARCINOGEN AS IDENTIFIED BY IARC, NTP OR OSHA.
Effects of Overexposure:IRRITATION AS NOTED ABOVE. ASPIRATION
PNEUMONITIS MAY BE EVIDENCED BY COUGHING, LABORED BREATHING AND
CYANOSIS (BLUISH SKIN); IN SEVERE CASES DEATH MAY OCCUR.
Medical Cond Aggravated by Exposure:PREEXISTING EYE, SKIN AND
RESPIRATORY DISORDERS MAY BE AGGRAVATED BY EXPOSURE TO THIS
PRODUCT.

First Aid:EYE-IMMEDIATELY FLUSH WITH PLENTY OF WATER FOR 15 MINS WHILE
HOLDING EYELIDS OPEN. GET MEDICL AID. SKIN-REMOVE CONTAMINATED
CLOTHES/SHOES & WIPE EXCESS FROM SKIN. FLUSH SKIN WITH WATER.
FOLLOW BY WASH ING WITH SOAP AND WATER. IF IRRITATION OCCURS, GET
MEDICAL AID. DO NOT REUSE CLOTHES UNTIL CLEANED. INHALATION-REMOVE
VICTIM TO FRESH AIR & PROVIDE BREATHING IF DIFFICULT. GET MEDICAL
AID. INGESTION-D O NOT INDUCE VOMITING. IF VOMITING OCCURS
SPONTANEOUSLY. KEEP HEAD BELOW HIPS TO PREVENT ASPIRATION OF LIQUID
INTO THE LUNGS. GET MEDICAL AID.

Flash Point Method:COC
Flash Point:=226.7C, 440.F
Extinguishing Media:USE WATER FOG, FOAM, DRY CHEMICAL OR CARBON
DIOXIDE. DO NOT USE A DIRECT STREAM OF WATER. PRODUCT WILL FLOAT &
CAN BE REIGNITED ON SURFACE WATER.
Fire Fighting Procedures:MATERIAL WILL NOT BURN UNLESS PREHEATED. DO
NOT ENTER CONFINED FIRE SPACE WITHOUT FULL BUNKER GEAR (HELMET WITH
FACE SHIELD, BUNKER COATS, GLOVES & RUBBER BOOTS), INCLUDING A
POSITIVE PRESSURE NIOSH A PPROVED SELF-CONTAINED BREATHING
APPARATUS. COOL FIRE EXPOSED CONTAINERS WITH WATER.

Spill Release Procedures:MAY BURN ALTHOUGH NOT READILT IGNITABLE. USE
CAUTIOUS JUDGMENT WHEN CLEANING UP LARGE SPILLS. ***SMALL
SPILLS***TAKE UP WITH AN ABSORBENT MATERIAL AND DISPOSE OF
PROPERLY.

Handling and Storage Precautions:STORE IN COOL, DRY PLACE WITH
ADEQUATE VENTILATION. KEEP AWAY FROM OPEN FLAMES AND HIGH
TEMPERATURES.
Other Precautions:DISPOSAL-ALTERNATIVELY, THE MATERIAL MAY BE RECYCLED.
CURRENTLY, HAZARDOUS USED OIL THAT IS RECYCLED BY BEING BURNED FOR
ENERGY RECOVERY IS MINIMALLY REGULATED UNDER RCRA. USED OIL THAT IS
RECYCLED IN ANY OTHER WAY IS CURRENTLY EXEMPT FROM SUBTITLE C
REGULATIONS. CHECK LOCAL & STATE AUTHORITIES FOR OTHER
REGULATIONS.

Respiratory Protection:USE A NIOSH-APPROVED RESPIRATOR AS REQUIRED TO
PREVENT OVEREXPOSURE, IN ACCORD WITH 29 CFR 1910.134. USE EITHER AN
ATMOSPHERE-SUPPLYING RESPIRATOR OR AN AIR-PURIFYING RESPIRATOR FOR
ORGANIC VAPOR AND PARTICULATES.
Ventilation:MECH(GEN)OR LOCAL EXHAUST THAT PROVIDES ADEQUATE
VENTILATION
Protective Gloves:WEAR GLOVES AS REQUIRED TO MINIMIZE CONTACT.
Eye Protection:WEAR CHEMICAL GOGGLES IF THERE IS LIKELIHOOD OF CONTACT
WITH EYES.
Other Protective Equipment:WEAR OTHER CLOTHING AS REQUIRED TO MINIMIZE
CONTACT.
Work Hygienic Practices:DO NOT RESUE CLOTHES UNTIL CLEANED. WASH WITH
SOAP & WATER BEFORE EATING, DRINKING, SMOKING OR USING TOILET
FACILITIES. LAUNDER CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
AVOID CONTACT WITH EYES. AVOID PROLONGED OR REPEATED CONTACT WITH SKIN.

HCC:N1
Spec Gravity:0.92
Solubility in Water:NEGLIGIBLE
Appearance and Odor:LIGHT AMBER OIL; SLIGHT ODOR.

Stability Indicator/Materials to Avoid:YES
AVOID CONTACT WITH STRONG OXIDIZING AGENTS.
Stability Condition to Avoid:AVOID HEAT, FLAME.
Hazardous Decomposition Products:CARBON MONOXIDE AND OTHER UNIDENTIFIED
ORGANIC COMPOUNDS MAY BE FORMED UPON COMBUSTION.

Waste Disposal Methods:THIS PRODUCT CONTAINS BADRIUM AT GREATER THAN
100 MG/L. UNDER EPA-RCRA (40 CFR 261.24). A WASTE MATERIAL THAT
CONTAINING BARIUM IS (HAZARDOUS WASTE NUMBER D0005). IF IT EXHIBITS
THE CHARACTERISTIC OF TOXICITY BASED UPON THE EXTRACTED
CONCENTRATION OF BARIUM AS SHOWN BY TCLP. REFER TO LATEST EPA OR S
TATE REGULATIONS REGARDING DISPOSAL.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.

Ecological:UNDER EPA-CWA, THIS PRODUCT IS CLASSIFIED AS AN AOIL UNDER
SECTION 311. SPILLS INTO OR LEADING TO SURFACE WATERS THAT CAUSE A
SHEEN MUST BE REPORTED TO THE NATIONAL RESPONSE CENTER,
800-424-8802.

Transport Information:DEPARTMENT OF TRASNPORTATION CLASSIFICATION: NOT
HAZARDOUS BY D.O.T. REGULATIONS.

SARA Title III Information:UNDER SARA TITLE III, SECTION 313, THIS
PRODUCT CONTAINS BARIUM COMPOUNDS.
Federal Regulatory Information:THE COMPONENTS OF THIS PRODUCT ARE
LISTED ON THE EPA/TSCA INVENTORY OF CHEMICAL SUBSTANCES.